A Research on Waste-Gated Turbine Performance Under Unsteady Flow Condition
| Autor: | Qingning Zhang, Qiyou Deng, Ludek Pohorelsky, Richard Burke |
|---|---|
| Jazyk: | angličtina |
| Rok vydání: | 2017 |
| Předmět: |
Cold start (automotive)
Engineering Pneumatic actuator business.industry media_common.quotation_subject Mass flow 020209 energy Mechanical Engineering Lumped capacitance model Energy Engineering and Power Technology Aerospace Engineering Mechanics 02 engineering and technology Inertia Turbine 020303 mechanical engineering & transports Fuel Technology 0203 mechanical engineering Nuclear Energy and Engineering Control theory 0202 electrical engineering electronic engineering information engineering business Actuator media_common Turbocharger |
| Zdroj: | Deng, Q, Burke, R, Zhang, Q & Pohorelsky, L 2017, ' A Research on Waste-Gated Turbine Performance Under Unsteady Flow Condition ', Journal of Engineering for Gas Turbines and Power: Transactions of the ASME, vol. 139, no. 6, 062603, pp. 1-12 . https://doi.org/10.1115/1.4035284 |
| DOI: | 10.1115/1.4035284 |
| Popis: | Turbochargers are key components of engine air-paths that must be carefully considered during the development process. The combination of fluid, mechanical and thermal phenomenon make the turbocharger a highly dynamic and non-linear modelling challenge. The aim of this study is to quantify the dynamic response of the turbocharger system across a frequency spectrum from 0.003Hz to 500Hz, i.e. for exhaust gas pulsation in steady state, load steps and cold start drive cycles, to validate the assumption of quasi-steady assumptions for particular modelling problems. A waste-gated turbine was modelled using the dual orifice approach, a lumped capacitance heat transfer model and novel, physics-based pneumatic actuator mechanism model. Each sub-model has been validated individually against experimental measurements. The turbine inlet pressure and temperature and the waste-gate actuator pressure were perturbed across the full frequency range both individually and simultaneously in separate numerical investigations. The dynamic responses of turbine housing temperature, turbocharger rotor speed, waste-gate opening, mass flow and gas temperatures/pressures were all investigated. The mass flow parameter exhibits significant dynamic behaviour above 100Hz, illustrating that the quasi-steady assumption is invalid in this frequency range. The waste-gate actuator system showed quasi-steady behaviour below 10Hz, while the mechanical inertia of the turbine attenuated fluctuations in shaft speed for frequencies between 0.1–10Hz. The thermal inertia of the turbocharger housing meant that housing temperature variations were supressed at frequencies above 0.01Hz. The results have been used to illustrate the importance of model parameters for three transient simulation scenarios (cold start, load step and pulsating exhaust flow). |
| Databáze: | OpenAIRE |
| Externí odkaz: |
|