Effect of Rice Husk Ash on Strength and Durability of High Strength High Performance Concrete

Autor: H. B. Mahmud, Syamsul Bahri, Y. W. Yee, Y. T. Yeap
Jazyk: angličtina
Rok vydání: 2016
Předmět:
DOI: 10.5281/zenodo.1123585
Popis: This paper reports the strength and durability properties of high strength high performance concrete incorporating rice husk ash (RHA) having high silica, low carbon content and appropriate fineness. In this study concrete containing 10%, 15% and 20% RHA as cement replacement and water to binder ratio of 0.25 were investigated. The results show that increasing amount of RHA increases the dosage of superplasticizer to maintain similar workability. Partial replacement of cement with RHA did not increase the early age compressive strength of concrete. However, concrete containing RHA showed higher compressive strength at later ages. The results showed that compressive strength of concrete in the 90-115 MPa range can be obtained at 28 curing days and the durability properties of RHA concrete performed better than that of control concrete. The water absorption of concrete incorporating 15% RHA exhibited the lowest value. The porosity of concrete is consistent with water absorption whereby higher replacement of RHA decreased the porosity of concrete. There is a positive correlation between reducing porosity and increasing compressive strength of high strength high performance concrete. The results also indicate that up to 20% of RHA incorporation could be advantageously blended with cement without adversely affecting the strength and durability properties of concrete.
{"references":["B.C. Lippiatt and S. Ahmad. Measuring the life-cycle environmental and economic performance of concrete: the BEES approach. in Proceedings of the International workshop on sustainable development and concrete technology. Beijing, 2004, 213-230.","D.N. Huntzinger and T.D. Eatmon, A life-cycle assessment of Portland cement manufacturing: comparing the traditional process with alternative technologies. Journal of Cleaner Production, 2009. 17(7): p. 668-675.","K.-H. Yang, Y.-B. Jung, M.-S. Cho, and S.-H. Tae, Effect of supplementary cementitious materials on reduction of CO2 emissions from concrete. Journal of Cleaner Production, 2014.","P.K. Mehta, Greening of the Concrete Industry for Sustainable Development. Concrete international, 2002. 23.","R.J. Detwiler and P.K. Mehta, Chemical and physical effects of silica fume on the mechanical behavior of concrete. ACI Materials Journal, 1989. 86(6).","FAO, Rice market monitor, vol XVIII. 2015, Issue 1.","P.K. Mehta. Properties of blended cements made from rice husk ash. in ACI Journal Proceedings. 1977. ACI.","K. Ganesan, K. Rajagopal, and K. Thangavel, Rice husk ash blended cement: assessment of optimal level of replacement for strength and permeability properties of concrete. Construction and Building Materials, 2008. 22(8): p. 1675-1683.","A. Ramezanianpour, M. Mahdikhani, and G. Ahmadibeni, The effect of rice husk ash on mechanical properties and durability of sustainable concretes, International Journal of Civil Engineering, 2009.7(2): p.83-91\n[10]\tP. Chindaprasirt, S. Rukzon, and V. Sirivivatnanon, Resistance to chloride penetration of blended Portland cement mortar containing palm oil fuel ash, rice husk ash and fly ash. Construction and Building Materials, 2008. 22(5): p. 932-938.\n[11]\tY.-Y. Kim, K.-M. Lee, J.-W. Bang, and S.-J. Kwon, Effect of W/C ratio on durability and porosity in cement mortar with constant cement amount. Advances in Materials Science and Engineering, 2014. 2014.\n[12]\tM. Safiuddin and N. Hearn, Comparison of ASTM saturation techniques for measuring the permeable porosity of concrete. Cement and Concrete Research, 2005. 35(5): p. 1008-1013.\n[13]\tA.M. Neville, Properties of concrete. 1995, Pitman, UK.\n[14]\tM. Pigeon and R. Pleau, Durability of concrete in cold climates. 2010: CRC Press.\n[15]\tM. Choinska, A. Khelidj, G. Chatzigeorgiou, and G. Pijaudier-Cabot, Effects and interactions of temperature and stress-level related damage on permeability of concrete. Cement and Concrete Research, 2007. 37(1): p. 79-88.\n[16]\tK. Kamaruddin and H.B. Mahmud, Absorption and permeability performance of Selangor rice husk ash blended grade 30 concrete. Journal of engineering science and technology, 2010. 5(1): p. 1-16.\n[17]\tR. Madandoust, M.M. Ranjbar, H.A. Moghadam, and S.Y. Mousavi, Mechanical properties and durability assessment of rice husk ash concrete. Biosystems engineering, 2011. 110(2): p. 144-152.\n[18]\tG.C. Cordeiro, R.D. Toledo Filho, and E.d.M.R. Fairbairn, Use of ultrafine rice husk ash with high-carbon content as pozzolan in high performance concrete. Materials and Structures, 2009. 42(7): p. 983-992.\n[19]\tG.A. Habeeb and H.B. Mahmud, Study on properties of rice husk ash and its use as cement replacement material. Materials Research, 2010. 13(2): p. 185-190.\n[20]\tH. Chao-Lung, B. Le Anh-Tuan, and C. Chun-Tsun, Effect of rice husk ash on the strength and durability characteristics of concrete. Construction and Building Materials, 2011. 25(9): p. 3768-3772.\n[21]\tW. Tangchirapat, C. Jaturapitakkul, and P. Chindaprasirt, Use of palm oil fuel ash as a supplementary cementitious material for producing high-strength concrete. Construction and Building Materials, 2009. 23(7): p. 2641-2646.\n[22]\tN. Van Tuan, G. Ye, K. Van Breugel, and O. Copuroglu, Hydration and microstructure of ultra high performance concrete incorporating rice husk ash. Cement and Concrete Research, 2011. 41(11): p. 1104-1111.\n[23]\tR. Sai, A. Juma, D. Prakash, S. Haider, and S.K. Rao, An Experimental Study on Synergic Effect of Sugar Cane Bagasse Ash with Rice Husk Ash on Self Compaction Concrete. Advances in Computer Science and its Applications, 2012. 1(2): p. 164-170.\n[24]\tV. Kannan and K. Ganesan, Chloride and chemical resistance of self compacting concrete containing rice husk ash and metakaolin. Construction and Building Materials, 2014. 51: p. 225-234.\n[25]\tG.R. Sensale, Strength development of concrete with rice-husk ash. Cement and Concrete Composites, 2006. 28(2): p. 158-160.\n[26]\tS.N. Raman, T. Ngo, P. Mendis, and H.B. Mahmud, High-strength rice husk ash concrete incorporating quarry dust as a partial substitute for sand. Construction and Building Materials, 2011. 25(7): p. 3123-3130.\n[27]\tS. Rukzon, P. Chindaprasirt, and R. Mahachai, Effect of grinding on chemical and physical properties of rice husk ash. International Journal of Minerals, Metallurgy and Materials, 2009. 16(2): p. 242-247.\n[28]\tH.B. Mahmud, M.F.B.A. Malik, R.A. Kahar and S.N. Raman. Mechanical properties and durability of normal and water reduced high strength Grade 60 concrete containing rice husk ash. Journal of Advanced Concrete Technology, Japan Concrete Institute, 2009,7(1): p 21-30. \n[29]\tE.J. Garboczi and D.P. Bentz, Computer simulation and percolation theory applied to concrete. Annual Review of Computational Physics, 1999. 7: p. 85-123.\n[30]\tV. Saraswathy and H.-W. Song, Corrosion performance of rice husk ash blended concrete. Construction and Building Materials, 2007. 21(8): p. 1779-1784.\n[31]\tV.M. Malhotra, Testing hardened concrete: nondestructive methods. 1976: Iowa State Press."]}
Databáze: OpenAIRE
Externí odkaz: