| Abstrakt: |
The aim of the study was to establish whether changes occur in respiratory function, particularly mucociliary clearance, among second fusion smeltery workers. The research covered 93 male smelters employed in steel forming and casting and 116 male workers of an electric power station, considered as non-exposed. Physiological, pathological and occupational histories of all subjects under study were available. An ECCS respiratory symptoms questionnaire was administered to all subjects ad the two groups also underwent a general medical examination, a spirometry and a chest X-ray. During the medical examination sputum was collected from the subjects to measure mucus transport rate on frog palate, expressed as Normalised Frog Palate Transport Rate (NFPTR). For the environmental research, dust, fumes and gas samplings were taken either at a fixed station or by means of personal dosimeters. Environmental research revealed very low concentrations of respiratory irritants (total dust: 0.2-6.8 mg/m3; respirable dust: 0.1-4.9 mg/m3; total silica: < 2-15.5%; respirable silica: < 0.004-0.3 mg/m3; iron: 0.008-0.085 mg/m3; chromium and manganese: < 0.001 mg/m3; fumes and gases: well below the TLV. The two groups were homogeneous with regard to age and smoking habits. Exposed workers showed rales, dyspnoea and spontaneous phlegm more frequently than non-exposed workers. NFPTR alterations were checked in 49 out of 81 exposed and in 18 out of 81 non-exposed subjects (chi squared = 22.9; p < 0.001). Stratification of the results according to smoking habits further confirmed the strong association between occupational exposure and NFPTR alterations. Smelters showed significantly lower mean NFPTR values compared to non-exposed subjects; also, the mean value of NFPTR in the exposed was below 0.70, which is considered the lowest individual limit in normal subjects. The only variable which explains a large part of the variability of NFPTR is past work in a smeltery rather than in an electric power station. The spirometries showed that only the mean PEF values were significantly lower among the exposed. Stratified analysis of the results according to smoking habits in the two groups revealed a close association between smeltery work and reduction of PEF to under 80% of the ECCS 1983 theoretical values, independently of smoking habits. We also compared the mean PEF values, both as measured values and as percent values of the ECCS 1983 theoretical values, stratified for occupational exposure and smoking; the results again showed that differences between these mean values were mainly due to current or past work in the foundry.(ABSTRACT TRUNCATED AT 400 WORDS) |
