Increasing the grind size for effective liberation and flotation of a porphyry copper ore by microwave treatment
| Autor: | A.R. Batchelor, D.A. Jones, Sam Kingman, S. Plint |
|---|---|
| Jazyk: | angličtina |
| Rok vydání: | 2016 |
| Předmět: |
Yield (engineering)
Materials science chemistry.chemical_element 02 engineering and technology engineering.material Porphyry copper deposit 020501 mining & metallurgy Liberation Grind Flotation Quartz Mineral Mechanical Engineering Metallurgy General Chemistry Mineralogy Geotechnical Engineering and Engineering Geology Copper Grain size 0205 materials engineering chemistry Control and Systems Engineering engineering Pyrite Microwave Ore |
| ISSN: | 0892-6875 |
| Popis: | In this paper, mineralogy, grain size, dissemination, textural consistency and mineral associations were determined for a commercially exploited porphyry copper ore using a Mineral Liberation Analyser (MLA). The ore was subjected to high power density microwave treatments in a single mode cavity at 15 kW and approximately 2 kW h/t. The untreated and microwave-treated samples were subsequently milled to two grind sizes near the nominal plant grind size and a size-by-liberation analysis performed. The analysis revealed that equivalent liberation could be obtained at a grind size approximately 50–60 μm coarser than the nominal plant grind due to the microwave treatment. Flotation testing indicated that an increase in copper recovery of approximately 1% could be achieved, or that a grind size increase of approximately 30 μm may potentially yield equivalent copper recovery due to the microwave-enhanced liberation observed. However, statistical analyses demonstrated that it is difficult to attain confidence in recovery increases of approximately 1% even when conducting batch flotation tests in triplicate. The ore under investigation had previously been shown to produce only modest average reductions in strength (∼8%) under similar microwave treatment conditions due to a prevalence of many unfavourable textures. However, the preferential association of copper minerals with a hard matrix mineral (quartz) and a hard microwave-absorbent mineral (pyrite) resulted in a significant change in liberation behaviour. |
| Databáze: | OpenAIRE |
| Externí odkaz: |
|
Full Text from ScienceDirect